Product ID:T-SERIES POWDER COATINGS
MSDS Date:07/16/1993
FSC:8010
NIIN:00N074661
MSDS Number: CCSBQ

CARDINAL INDUSTRIAL FINISHES

1329 POTRERO AVE
SOUTH EL MONTE, CA 91733
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 818-444-9274

Preparer: ROBERT H. SYPOWICZ

Cage: 65860

CARDINAL INDUSTRIAL FINISHES

SOUTH EL MONTE, CA 91733 US

Telephone: 818-444-9274 OR 213-283-9335

Cage: 65860

0 @ 20C.

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 0-5%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

S-TRIAZINE-2,4,6(1H,3H,5H)-TRIONE, 1,3,5-TRIS

CAS: 2451-62-9

RTECS: XZ1994900

Fraction By Weight: 0-10%

OSHA PEL N/K

ACGIH TLV: N/K

0 @ 20C.

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

2H-AZEPIN-2-ONE, HEXAHYDRO-; (E-CAPROLACTAN) (0.5%). (MFR'S

CAS: 105-60-2

RTECS: CM3675000

Fraction By Weight: 0-5%

OSHA PEL 1 MG/M3 (MFR)

ACGIH TLV: 6 MG/M3 (MFR)

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

0 @ 20C.

CAS: 7727-43-7

RTECS: CR0600000

Fraction By Weight: 0-40%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

EXCLUDING WATER -

RTECS: 9999999VO

APPROVED PARTICLE MASK/RESPS SHOULD BE USED WHERE

RTECS: 9999999ZZ

PREVENT RPTD/PRLNG SKIN CONT W/GB PROT

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES:CAN CAUSE IRRITATION AND REDNESS,
TEARING OR BLURRED VISION. SKIN:IRRITATION, RASH AND DERMATITIS
POSSIBLE FROM PROLONGED EXPOSURE. INHALATION:NASAL IRRITATION,
HEADACHE, DIZZINESS, NAUSEA, WEAKN ESS OR VOMITING.
INGESTION:GASTRO-INTESTINAL IRRITATION, NAUSEA, DIARRHEA,
DROWSINESS, LOSS OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CARBON BLACK:IARC MONOGRAPHS ON EVAL OF
CARCIN RISK OF CHEMS TO MAN, VOL 65, PG 24-27, 1995:GROUP 2B.
Effects of Overexposure:HLTH HAZ:CONSCIOUSNESS, STATE OF SHOCK, WEAK &
RAPID PULSE & COLD PALE COMPLEXION. PAINTS & COATINGS HAVE BEEN
LINKED TO LIVER ABNORMALITIES, KIDNEY & LUNG DAMAGE. ALTHOUGH THIS
COATING IS A POWDER OF LOW TOXICITY, FOLLOW PRECS OF THIS MSDS TO
PREVENT OVEREXPOSURE.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
CONDITIONS, PRE-EXISTING SKIN DISORDERS, LIVER & KIDNEY DISORDERS.

First Aid:EYES:FLUSH W/WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION IMMEDIATELY. SKIN:WASH EXPOSED AREA W/SOAP & WATER.
REMOVE CONTAMINATED CLOTHING. INHAL:REMOVE TO FRESH AIR. IF
BREATHING IS DIFFICULT , ADMINISTER OXYGEN. IF BREATHING HAS
STOPPED, GIVE ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION.
INGEST:DO NOT INDUCE VOMITING. KEEP PERSON WARM & QUIET. GET
MEDICAL ATTENTION.

Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NOTE:THIS PROD IS DRY PWDR & UNDER NORMAL
OPERATING RISK PRESENTS MIN RISK OF FIRE/EXPLO. HOWEVER, PROPER
STOR & CAUT IN HNDLG & USE PRACTICES SHOULD BE(SUPDAT)

Spill Release Procedures:REFER TO OTHER SECTIONS OF THIS MSDS.
ELIMINATE ALL IGNITION SOURCES. SWEEP UP SPILLS & PLACE INTO DRUM
OR OTHER SEALABLE CONTAINER. AVOID GENERATING DUST FROM CLEAN-UP OF
MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN COOL, DRY PLACE & PROT FROM
BREAKAGE. AVOID STORE AT TEMPS >80F. AVOID EXCESSIVE
MOISTURE/HUMIDITY. KEEP CNTNRS TIGHTLY SEALED.
Other Precautions:DO NOT STORE NEAR OVENS/SOURCES OF EXTREME HEAT. DO
NOT ALLOW PWDR DUST TO ACCUM NEAR MACHINERY/SOURCES OF IGNIT. PWDR
COATINGS SHOULD BE APPLIED ONLY W/PROPER APPLICATION EQUIP W/IN
PROPERLY VENTED C ONTROL ENCLOSURE. PWDR COATING (SUPDAT)

Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED, A
NIOSH APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF ENVIRON
CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH APPRVD RESPS UNDER
SPECIFIED CNDTNS. (SEE YOUR SF TY EQUIP SUPPLIER).
ENGINEERING/(SUPDAT)
Ventilation:PROVIDE SUFFICIENT APPRVD MECH (GEN &/OR LOC EXHST) VENT TO
CONTROL DUST ACCUMULATION & MAINTAIN EXPOS BELOW TLV'S.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . PROT CREAM IS SUGGESTED FOR MANUAL SPRAY EQUIP OPERATORS.
(ING 8)
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING REST ROOM.
SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
EXPLO HAZ:USED AT ALL TIMES. OTHER PREC:EQUIP SHOULD BE GROUNDED AT ALL
TIMES TO PVNT STATIC ELEC BUILD-UP. (OSHA 29 CFR 1910.107). NO OPEN
FLAMES/SOURCES/SPK PRDCG EQUIP SHALL BE LOCATED W/IN 20 FT O F PWDR
USE, UNLESS SEPARATED BY PARTITION. RESP PROT:ADMIN CONTROLS SHOULD
BE IMPLEMENTED TO REDUCE EXPOS. NIOSH (ING 7)

Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.2-1.8
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:POWDER OF VARIOUS COLORS.
Percent Volatiles by Volume:<3

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:WHEN EXPOSED TO EXTREME HEAT,
DECOMPOSITION PRODUCTS MAY YIELD, OXIDES OF CARBON & NITROGEN OR
TOXIC FUMES.

Waste Disposal Methods:REUSE OR RECYCLE WHENEVER POSSIBLE, DESTROY
WASTE SOLIDS BY INCINERATION OR DISPOSE IN LANDFILL I/A/W LOCAL,
STATE & FEDERAL REGULATIONS. CONTAINERS OR BOXES OF MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED, SINCE EMPTIED CNTNRS RETAIN PROD
RESIDUALS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.